Tel No. (+86) 371-55629010

portable gas water boiler

Measures to increase the gas steam boiler economy which economy improving gas steam boiler can not only reduce operating costs, but also in line with the national energy saving policy requirements. Specifically refer to the following measures: 1, to improve equipment management level, efforts to reduce internal and external leakage thermal equipment and systems, reducing the working fluid and heat loss. 2, improve the economy auxiliary operation, to reduce the loss of auxiliary equipment, making it possible to run in the high zone. By testing to determine its associated auxiliary systems of reasonable conditions in the different operating modes of operation, efforts to reduce power consumption rate. 3, chemical strict supervision of the boiler operation, strict control of condensate water hardness, the amount of dissolved oxygen in the feedwater, boiler feed water and the PH value of water, steam quality, to prevent the boiler heating surface, condenser, heater, and corrosion of turbine flow section, fouling and salt accumulation caused by the deterioration of boiler equipment operating conditions. 5, to take measures to save water and power, such as to maintain a reasonable rate of circulating water is concentrated, and to improve the ratio of gray water recycling waste ash comprehensive utilization. 6, the main measures of force cycle efficiency is the main steam pressure, main steam temperature, reheat steam temperature is maintained at a predetermined value, back to normal investment in thermal efficiency, water temperature in the design value, efforts to reduce back pressure steam turbine and so on. 7, to improve the efficiency of the steam boiler, a steam boiler to reduce the exhaust gas temperature, air leakage rate boiler fly ash combustible content, good milling system to adjust combustion boiler test, develop various conditions of operation of the card, as the operator operating personnel in accordance with. Yaoan gauge 8, to strengthen the fuel management, strict measurement, strict control of coal into the plant, allowing coal from the design value is within the limit value, especially for volatile coal, ash, sulfur, strict supervision coking characteristics the boiler can run under good conditions. 9, strengthen metrology run, the boiler operation indicators to quantitative analysis, provide a reliable basis for the economic operation of the steam boiler. Zheng gas steam boiler pot consists of three parts: main boiler, chimney and piping system, wherein the host section has been completed and the chimney is manufactured in the factory, the host supporting the pipes and valves, the meter has been properly installed randomly transported to the host site and can be assembled chimney. Field gas supply is turned on, power supply, water line to test. Greatly reducing the installation cycle, and can ensure product quality.

How to start running hot portable water boiler? When the exhaust valve is completely steam drum, main power start-up burner, and check off the boiler inlet, and a valve hole flange hand, when the air pressure rises to 0.05 ~ 0.1Mpa, add water, sewer, water supply system check experiment and sewer facilities. Hot water boiler boiler assembly PC-style controller, all functions are stored on a smart chip, intelligent boiler, digitization, automation, humane, intelligent control of boiler water temperature, water temperature reached the heating automatically stop; large screen fonts display temperature, boiler water temperature at a glance. Biomass boiler categories: biomass boilers Horizontal, vertical biomass boilers. Biomass gas thermal oil heaters, biomass steam boiler, biomass hot water boiler, biomass oil furnace. Function gas boiler the ignition system that ignites the mixture of air and fuel, its main components are: the ignition transformer, the ignition electrode, a high voltage electrical cable fire. A more secure electronic ignition system called ignition pulse, is widely used Zhuoyi energy saving gas boiler manufacturers. Which facilitate saving, can simply press a finger, and safe, does not occur due to unexpected accidents occur flame, once the stall state occurs, the control system can close the solenoid valve, off the gas passage. When flush water gauge pressure rises to 0.1 ~ 0.15MPa, flushing water gauge pressure rises to bend 0.3MPa, fire load / small fire knob is rotated in the direction of fire. When the combustion pressure strengthened, the operating pressure is increased to 2? 3, starts to supply gas heating pipe, the water discharge valve is completely closed when the hammer, slowly open the main steam valve, to prevent water hammer is discharged from steam discharge valve, the main valve is closed after the air the main air valve was slowly opened to the full, and then inverted semicircular burner control knob active level adjustment, according to a load level adjustment (to manually start and stop the pump), at low load and high load level should be slightly higher than the normal level, slightly below the normal level of water vapor pressure adjustment: adjusting the combustion load in accordance with (manual adjustment fire / small fire) determining combustion, the combustion is adjusted to the best condition.

10 tph and 6 tph SZS series water tube gas-fired steam boilers for food industryIn the production processes of various seasoning vegetables including pickled vegetables, steam supplied by the boiler is required for processes such as high temperature sterilization and heating. Sichuan Jixiangju Food Co., Ltd. is a Sino-Korea joint venture committed in research, production and sales of high-grade seasoning vegetables and pickled vegetables. The products are sold all over the country and exported to many countries and regions overseas.In 2017, with the increasingly serious environmental issues, Jixiangju Food actively responded to the national "coal to gas" policy and decided to purchase low NOx gas-fired steam boilers. As a long-term partner of ZOZEN, Jixiangju Food expressed satisfaction with the operation of the coal-fired boilers previously purchased from ZOZEN. For the new demand proposed by Jixiangju Food, ZOZEN customized the boiler system and recommended two sets of SZS low NOx steam boilers to ensure the sufficient steam supply for the production line. This series of gas-fired boilers adopts D-type full-membrane wall structure, and the combustion chamber adopts Narrow pitch tube membrane water-cooled wall, which has good air tightness and reduces heat loss. It is equipped with energy-saving equipment added at the tail of the boiler flue to improve the thermal efficiency over 98%; the large-volume furnace design combines the advanced low NOx burner to ensure that the NOx emissions in the boiler flue gas is less than 30mg/m³, which has passed the environmental protection standards.

To ensure the safety of special equipment such as boilers, in normal use, to further promote the comprehensive management of environmental pollution, since April this year, Khorgas Market Supervision Administration of Quality Supervision Bureau for the joint Yili area within the jurisdiction of Khorgas , launched a special safety inspection activities boilers.

Law enforcement officers to be included within the jurisdiction of the major hazard of 12 boiler units of a total of 21 boilers individually conduct a special inspection, focus on examination of the "three implementation, two certified, a test, a plan," the implementation of a detailed view of boiler safety management system, run records.

Test results showed that most of the boiler unit security management more standardized, but there are still some units use boilers run records were incomplete, part of the boiler has to inspection cycle, has been scrapped or dismantled boiler is not write-off and other issues, law enforcement officers to issue on-site boiler sealed, and ordered boiler unit for rectification.