Tel No. (+86) 371-55629010

2t Oil Boiler Tajikistan

Now on the market most of the 2t boiler tajikistans to gas, oil, biomass, electricity as the main fuel, coal-fired boilers because of its harmful pollution levels gradually been changed or replaced. In general, no boiler explosion during normal operation, but if it is due to the improper operation of the ignition or operation, it may cause the furnace or tail or secondary combustion flue explosion, resulting in serious danger of impact. In this case the role of "explosion vent" is manifested when the furnace or flue trace knocking occurs, the pressure within the furnace is gradually increased, when a certain value is higher than the pressure relief device can turn on itself through the explosion vent to avoid the risk expansion to ensure the overall safety of boiler and furnace wall, more importantly, it is to protect the safety of the boiler operator. Currently there are blasting boiler membrane and two kinds of swing-proof door.

Steam 2t boiler tajikistan furnace operating point first launched circulating pump equipment circulating pump outlet, into the furnace, the pressure released, and the system back to the oil pressure, make sure that in the positive practice mode. Circulation pump run for 30 minutes, after the stable operation of the system before it can enter the next step. Open gas pipeline manual valve steam boiler, burner launch button, natural gas burner into the furnace, and then burned, keeping the flame stable condition, is in the safe operation of the equipment. Incineration steam boiler, once the accident shut down if the phenomenon occurs, the device will take the initiative burner interlock protection status, should be promptly cut off natural gas pipeline, launched a purge function of the furnace, the furnace inside air replaced more than clean shutdown. System according to load requirements, temperature requirements and thermal oil outlet, the burner can be actively adjust the size of the amount of fire. Steam boiler heat exchanger is generally divided into two, one is directly touch the touch exchanger, and the other is the direct heat exchanger, which are separate apparatus for flue gas waste heat recovery, energy saving effect complete . Generally steam boiler practices can be simple progress through the transformation of energy-saving action, such as increasing the waste heat recovery equipment installed on, which is energy-saving advantages of steam boilers. Energy savings from the big side, is to promote the cause of saving the country, to say that small ways to create more profits for the company to save costs, the choice of one of the heat exchanger is a good way to complete energy policy.

Fuel oil (heavy oil), natural gas, dry gas, gas and coal as a 2t boiler tajikistan fuel, in order to prevent an explosion or detonation furnace in operation, the wind must be at least 5 minutes before ignition; ignition should be given a torch and is not permitted heat ignition furnace; furnace temperature operation combustible material is not too high, blast, to balance with the amount of the wind.

"Euromonitor" closed series of 2t boiler tajikistan condensate recovery system, the condensed water directly into the boiler temperature, with three-pass boiler air preheater + + economizer, full use of the flue gas heat recovery and then the temperature condensate from the source use, reducing energy waste and significant cost savings for businesses, the effect is immediate.