As our 6000kg coal wood biomass fired industrial boiler prices engineer said, external circulating fluidized bed boiler lighting up is much easier than internal circulating fluidized bed boiler. This is because external cfb boiler adopts automatic ignition method, burning oil to start the whole boiler system at first. However, internal cfb boiler still uses manual ignition method, burning biomass pellet like wood to run the whole boiler equipment. As to boiler system cost, external cfb boiler is more expensive than internal cfb boiler.
Circulating fluidized bed combustion(CFBC) Advantages :
1. Fluidized bed can burn a variety of fuels-coal as well other non-conventional fuels like biomass, petro-coke, coal cleaning waste and wood. This bed contains only around 5 percent coal or fuel. The rest of the bed is primarily an inert material such as ash or sand. Fluidized bed boilers are capable of burning a wide range of fuels cleanly, including biomass fuels such as wood waste.
2. The Temperature in FBC is around 800-900°C compared with 1300-1500°C in pulverized coal combustion (PCC). Low Temperature helps minimize the production of NOx (nitrogen oxides). With the addition of a sorbent into the bed (mostly limestone), much of the so2 formed can be captured. The other advantages of FBC are Compactness Ability to burn low calorific values (as low as 1,800 kcal/kg) Production of ash which is less erosive. Moreover, in FBC, oil support is needed for 20-30 percent of the load versus 40-60 percent in PCC. FBC based plants also have lower capital costs compared to PCC based plants. The capital costs could be 8-15 percent lower.
DZL series corn cob biomass 6000kg coal wood biomass fired industrial boiler prices, also has some differences with other biomass boiler in design. Our engineer will design and adjust the boiler internal structure to reach its highest combustion efficiency when only burning corn cob fuel. Its boiler also can burn other biomass fuels like wood pellet, bagasses, palm shell, etc, but burning those fuels can not reach the highest points.
Industrial production is inseparable from 6000kg coal wood biomass fired industrial boiler pricess, emission control of atmospheric pollutants boiler air pollution control in Shanghai to expand and intensify the focus of the project. Currently, Shanghai Industrial boilers alternative clean energy has been completed, nitrogen oxides (NOx) emissions of major pollutants as a boiler, the boiler due mostly low shelf emission source of ambient air near the ground and ozone greater PM2.5 influence, therefore, this release the new standard, the boiler will be low-nitrogen transformation, improve Shanghai air quality, protect people's lives and health and other aspects demand a strong thrust of great significance. Throughout the country, Beijing, Tianjin and other places have started low-nitrogen transformation boilers for low-nitrogen transformation has a more mature technology reserves. Based on the above considerations, for the effective control of NOx emissions from boilers, to further deepen cooperative control of PM2.5 and ozone, according to the standard first, to further accelerate the transformation of governance principles, it is necessary once again to revise the standard boiler.
According to local environmental standards and revision procedures, the Municipal Environmental Protection Bureau held a meeting to hear the relevant departments, enterprises and the opinions and suggestions of experts, and in 2017 August 4 to September 15 in the online open standard full text to solicit public opinion. At the same time the Ministry of Ecology Environment solicit written opinions Municipal Development, City Commission by letter and other related commissioned Bureau, industry organizations and boilers, production units and other enterprises. Municipal Environmental Protection Bureau and the Municipal Quality and Technical Supervision on January 19, 2018 organized the expert technical review meeting, the panel agreed that standards through technical review. Approval by the Municipal Environmental Protection Bureau and the Municipal Quality and Technical Supervision audit report to the municipal government.
The new standard has been revised for several aspects, one is no longer on the "central heating boiler and the nominal amount of evaporation less than 65t / h boiler cogeneration" provisions alone time; the second is to simplify the original class standard boiler merged into " gaseous fuel boiler "and" boilers "categories; are three different degrees of contamination tightened limits particulate matter, sulfur dioxide and nitrogen oxides; four new boiler is implemented from the date of implementation of this standard, the boiler given a transition period of about two years.
New standards for gaseous fuel boiler particulate matter, sulfur dioxide and nitrogen oxides are applied strict limits, but mainly considering the control of nitrogen oxide emissions, and further improve air quality. In the transition period boiler (1 October 2020) to limit nitrogen oxide 150mg / m³; after a transitional period of 50mg / m³. Date of implementation of new boiler nitrogen oxides from standard starting execution 50mg / m³ limit. Taking into account the comprehensive utilization of straw in Shanghai, biomass fuel boilers follows the standards of the original project control and limit requirements.