Tel No. (+86) 371-55629010

used coal boiler

36MW palm and biomass power plant in Malaysia

ZG once setup 75ton biomass power plant boiler in Malaysia, The article below is talking about anoter palm biomass power plant built in Malaysia with 36MW. ZG provide biomass power plant to a palm oil industry,the African oil palm, is the world'smost productive energy crop. Not only does its fruit bunches yield vast amounts of oil that can be used to make biodiesel, a plantation also delivers ligno-cellulosic biomass that can be used as a feed stock for second generation ethanol, and the oil-production process yields copious amounts of residues that find use in biogas production, as a bioenergy feedstock for co-firing with coal or as base chemicals for the production of bioplastics and a series of highly valuable biomaterials.

wns oil and gas used coal boiler details

The wns series oil and gas boiler is a fire tube boiler produced by ZG boiler. And WNS series gas and oil fired boiler is the sub-project of high efficiency (up to 95% thermal efficiency) and eco-friendly boiler under the World Bank’s GEF Program. As you can see from the name, this boiler fuel design is natural gas, oil, biogas, etc. These fuels have advantages in some respects compared to biomass fuel, coal and other energy sources. These fuels are transported in the form of pipelines. This means that the oil and gas boilers do not need to be treated and stored for combustion, which reduces the footprint of the boiler plant and reduces the cost of the site.

Condensing a portion of the air preheater and use of double combination economizer design. Internal economizer heat exchanger elements using the new technology - the wings of the tube instead of finned tubes, a five-fold increase in heat transfer area at the same volume, latent heat of vaporization of the portion of the flue gas is sufficiently absorbed, effective utilization of the fuel energy, energy saving at the same time enhance the efficiency of the use of the used coal boiler. Air preheater is further absorbed by the air and the flue gas convection heat latent heat of flue gas, and the air heated by the air preheater is connected directly into the burner tube, providing warm air for the fuel, thus improving combustion efficiency. This exhibition brings Chinese fast "Euromonitor" series boilers attracted a large number of customers, to give customers unlimited. Here, fast Boiler staff wish the exhibition every success.

Several factors underlie the vertical steam used coal boiler efficiency China has been working to catch on coal to natural gas, vertical steam boiler with greatly reduced contamination of dust, smoke and other effects of a nitric oxide gas has also been healthy curb. Efficiency is an important indicator of a measure of vertical steam boiler, a good number of factors under the topic to discuss the direct impact of vertical steam boiler efficiency began. After analysis of stakeholders, heat loss from vertical steam boiler contains two pieces: the proportion of full combustion air with flue gas emissions unreasonable heat loss. Heat loss can be reduced smoke emission can be installed at the end of the vertical steam boiler stack waste heat reuse install, or more leading system with condensing boiler. Combustion air ratio sufficient unreasonable faults into: general vertical ejector-type steam boiler burner selection, resulting in a motor fuel ratio can not be adjusted. Most of the selected vertical steam boiler is mechanically strong emission combustion engine, air-fuel ratio resulting irrational factors are the following: air-fuel ratio can be divided into two reasonable chance comprising: when the air in excess, the excess will have full cold It is heated, resulting in increased operating costs vertical steam boiler, steam boiler efficiency vertical drop; when the air is not enough, will produce insufficient burning phenomenon, caused by vertical steam boiler efficiency.