Electric heating coal fired condensing steam boiler supplier to bring clean air to generate electric heating steam boiler for your life can be said to greatly improve the problem of environmental pollution and energy saving issues, while electric heating steam boiler changed the traditional old-fashioned coal-fired boiler volume great ills, developed the electric heating steam boiler is very small, beautiful, energy-saving and environmental protection is on the leader. The traditional coal-fired boilers serious waste of energy coal This one-time, while there are still major problems of environmental pollution, the gradual strengthening of national environmental awareness of today no longer adapt to market development, which also makes the development of electric heating steam boiler. Enjoy our life is not just well-off life, as well as the air is clean. Electric heating steam boiler products can bring clean air to your life. Electric heating steam boilers in coal-fired boilers than just on the price a little high, but in the long run (environmental protection and energy efficiency) electric boiler products are very affordable, we should not give up on him a little bit expensive, so may be set would be wasted.
Why horizontal gas coal fired condensing steam boiler supplier to run under negative pressure? Horizontal Gas-fired steam boilers are generally negative pressure operation, if the pressure is running high temperature flue gas will cause the furnace to burn jet furnace walls and insulation, but also endanger the safety of operating personnel , the negative pressure is not too large, generally -10 ~ -30Pa, small oil-fired boiler is generally because there is no draft fan for the combustion positive pressure. For improving the thermal efficiency of the boiler has the following methods: a low pressure industrial boiler manufacturers has been designed in consideration of the problem of overheating efficiency, device, or change from the flue gas energy aspects is not possible and thus the best energy boiler operation starting from the (here not On the recovered water of vapor condensation). According to statistics survey, the current design of the thermal efficiency of domestic low-voltage industrial boilers is generally 70 to 90%, generally the actual operation of the thermal efficiency of about 60 to 80%, some even below 50%, a small low pressure industrial boilers as long as the operation, maintenance properly, design can achieve the thermal efficiency of the boiler manufacturers. I think the management and operation of the boiler should pay attention to the following points: First, to monitor the boiler exhaust gas temperature. Usually the largest boiler flue gas heat loss is a loss, so control the boiler flue gas temperature is very important, general industrial boilers low pressure gas (mainly refers to less than 10 tons of boiler and pressure of 1.6MPa, the same below) of the exhaust gas temperature is 150 ~ 180 ℃, oil-fired boiler exhaust gas temperature is 210 ~ 240 ℃, when the exhaust gas temperature is too high to find the cause and timely elimination. Causes of high temperature exhaust gas boiler are: a chamber negative pressure is too high, short-circuiting flue gases, the heat pipe 3 soot is too thick, too thick scale pan 4, etc., oil-fired boiler exhaust gas temperature is too high reasons : 1 air not adjusted oil, the oil is not completely burned in the chimney secondary combustion occurs aft, 2 soot too, the need for timely cleaning, the flue gas short circuit 3, 4 is too thick scale, etc. second, the control of boiler blowdown rate. General industrial boiler blowdown rate controlled at 5 to 10%, in the pot of water to ensure that qualified (mainly total alkalinity and pH) under the premise of boiler blowdown rate as low as possible, the sewage to adhere to the "ground row, row less, uniform discharge "principle. Third, the maintenance of good boiler furnace wall insulation. Boiler heat loss is also a relatively large heat losses, now the boiler manufacturers in the manufacturing and design has been well thought out, so we do not need to change, we just trying to be difficult to maintain. Outsourcing surface temperature generally does not exceed the boiler 50 ℃, such as too high will have to find out the reasons, timely elimination. Boiler insulation should always be kept dry for gas boilers, pressure must not run long, or easy to damage the coal furnace wall and gate and so on. Fourth, adjust the ratio of fuel and air volume, complete combustion of the fuel as possible. Small boilers generally do not have the amount of wind testing instruments, we can only go by experience adjustment. For oil-fired boiler, the normal combustion flame was yellow-white, non-glare, flame stability, no visible smoke chimney; for gas boiler, the normal combustion flame as a light yellow, no visible smoke stack, substantially cinder burn coal particles as uniform as possible. Fifth, there must be complete boiler water treatment. Complete boiler water treatment and water quality testing can maximize prevent boiler scaling and correct guidance of the sewage, but it did not do a lot of small boilers, companies usually do not pay attention.
Recently, in Qinghai Province Jigzhi County Market Authority carried out a special inspection of boiler safety within the county, mainly in order to further strengthen the special equipment safety supervision, investigation and potential risks.
County Market Authority was held on June 8 special meeting to make arrangements for this special inspection work; the meeting, Secretary of this special inspections put forward specific requirements: Either the county government and relevant departments in accordance with the superior, all in the area to check boilers, boiler and disabled to look back, to verify the implementation of the rectification; the second is to designate a person to carry out checks to ensure that this special inspection into effect, produce results; the third is to check violations found to be severely dealt with according to law.
Subsequently, according to the spirit of the meeting, Jigzhi County Market Authority Board redoubling its efforts to carry out special inspections. 5 out of law enforcement officers were examined using 10 units. The county has been reported to stop the boiler After registering with and eleven inspection and verification. Focus on checking whether the boiler inspection, whether the registration, check whether safety accessories in place, whether fireman certificates and other issues, focusing on correct pressure boilers, waste heat and pressure tanks and other equipment as well as the use of pressure boiler overpressure operation and other illegal operations behavior, found hidden among all checks for disposal in accordance with law, to ensure the safe operation of the boiler county.
Next, the county will further increase the pressure in the boiler with supervision and do routine inspections and safety management, strengthen the use of units to pay a return visit found the problem of checks put in place to promote the use of the unit responsibility, and earnestly safeguard the life and property Safety.
10 ton gas fired steam boiler for sale in ZG Boiler is a “D” type double drums water tube boiler, and its furnace hearth is adopted with membrane water wall structure. The 10 ton gas fired steam boiler has a good fuel application, such as light oil, heavy oil, natural gas, liquefied gas, city coal gas and so on. And it has the following advantages: compact structure, small occupation area, good degree of flame; Good thermal insulation performance; With automatic burner, high combustion efficiency; Multiple protection function, safe and reliable operation; ISO9001-2008, IBR and ASME certifications.