Tel No. (+86) 371-55629010

high pressure boiler principle

Electric steam high pressure boiler principle before the operation using the operating electric steam boiler 1. The apparatus used should be turned off drain valve, supply valve, inlet valve open, check the power supply is normal. 2. When the controller stops the alarm by pressing the power switch, the switch to Ⅲ heating profile, alarm controller (due to lack of water in the boiler), while the indicator light replenishment pump starts to operate, to pay low water levels, a high level continues automatic replenishment , water pumps stop, boiler heating lamp is lit, the boiler automatically start heating. 3. When the boiler pressure reaches the set value, the heating switch to Ⅱ, this time to turn the steam valve, the use of steam. 4. When using steam, the furnace pressure drop, when the pressure dropped to the lower limit set value, the heating boiler starts automatically. 5. When steam is used, oven declining water level when the water level falls below the low, i.e. start the pump, a high level of replenishment to the furnace, the boiler heating cycle automatically. When the water level is below the low water level, and supply system is not working properly, after 10 seconds the water level does not reach the low water level electrode, the controller continuously alarm and shutdown protection. 6. Use process to maintain the boiler pressure at about 0.4Mpa, if necessary, by heating the toggle switch adjustment. 7. The use of the process, such as more than 15 seconds duration alarm alarm, should immediately check off the soft water tank is normal. 8. The work is completed, press the power switch off the power, power light is off.

Gas hot water high pressure boiler principle examples of some professional issues and answers on the type of boiler, the following explanation will be focused on, and this one is for the gas hot water boiler, because this is one of the important types of boilers, and its use is relatively Many. Therefore, it is necessary to learn in this regard, so that we are familiar with this kind of boiler, so as to enrich their knowledge. 1. gas hot water boiler, its spare parts, mainly there are few? On this kind of boiler, there is no economizer or air preheater, it will affect the exhaust gas temperature? Gas hot water boiler, its spare parts, mainly, there is a boiler control cabinet, three burners and chimneys. As for whether there is economizer or air preheater, it will affect the exhaust gas temperature of the boiler, and if not, the exhaust gas temperature is 200-220 degrees; any, may be reduced to 180 degrees. 2. gas hot water boiler, the flue gas condenser should be installed in what position, more appropriate? Mounted on the gas hot water boiler flue gas condenser, in general, is mounted on the boiler return pipe, is more appropriate. Since this installation, it is possible to increase the boiler water temperature, and the thermal efficiency. Moreover, it is possible to reduce costs and achieve energy conservation, it can be said that a lot of benefits. 3.58-megawatt gas-fired boiler quite a few tons of gas hot water boiler? And a gas hot water boiler, tonnage and heating area, what is the relationship between these two? 58 MW gas-fired boiler, which from a professional point of view, then, which is equivalent to 83 tons of gas hot water boiler. In the gas hot water boiler, tonnage and heating area, it is directly proportional to the relationship, that is, the greater the tonnage, the greater its heating, then the greater the heating area. These can be said, it is an important intellectual content gas hot water boiler, at the same time, we also need to master in order to be able to practice in a reasonable and proper use of this kind of boiler, to get satisfactory results. Thus, to increase the use value of the boiler.

The fact that we determined to achieve cooperation with the fast high pressure boiler principle is a very wise decision, after a period of time put into the boiler efficiency significantly much higher than our original boiler efficiency, significantly reduce fuel costs, the economic benefits brought by the boiler is obvious. --customer feedback

You know Btu high pressure boiler principle do? Let Henan fast boiler manufacturers tell you to! As we all know, the boiler is an energy conversion device. Chemical energy into the boiler, electrical, high temperature flue gas heat and the like. After the boiler, the steam output have a certain heat, hot water or organic heat carrier. Today, let Henan fast boiler manufacturers tell your boiler thermal units.