Tel No. (+86) 371-55629010

18tons szs gas hot water boiler shipped to Argentina

Jingzhou City, Hubei is located in Jianli County Supervisor Bureau for a food processing plant emergency inspection and maintenance, the timely processing of the security risks of the boiler. At the meeting held later, the city supervisor Bureau emphasized the specific guidance boiler safety management.

How to combine gas steam boiler when a parallel gas steam boiler / steam boiler two or more than two runs, the new operational boiler steam supplied to the total charge of steam, the furnace is called parallel, how a natural gas steam boiler is operating analysis of: (1) steam boiler gas before the merger, should decrease the fire. Gas-fired steam boiler burner underlying mode, two-pass configuration, the fuel combustion, the boiler operation is stable and take up less space, while the spoiler is inserted smoke tube, smoke slow speed, increase heat transfer, a high thermal efficiency, reducing the total cost of the user is provided drain pipe, the water shall be discharged, and then washing water level gauge, the normal water level is maintained below the water line. (2) At this time, the steam pressure gas steam boiler is reduced, when the steam pressure is below the vapor piping system pressure of about 0.05MPa, the water level can be in communication with the furnace. Biomass boiler categories: biomass boilers Horizontal, vertical biomass boilers. Biomass gas thermal oil heaters, biomass steam boiler, biomass 18tons szs hot water boiler shipped to argentina, biomass oil furnace. (3) a combination of steam gas boiler, a main steam valve should be opened slowly. When the main steam pipe soda no impact should open the main steam valve, to observe changes in water level. (4) Complex fire, pay attention to the steam boiler water, maintain the normal operation. Gas-fired steam boiler burner underlying mode, two-pass configuration, the fuel combustion, the boiler operation is stable and take up less space, while the spoiler is inserted smoke tube, smoke slow speed, increase heat transfer, a high thermal efficiency, reducing user fees gas steam boiler drum double lateral structure, completely overcome the bulging phenomenon boiler superheater tubes are directly exposed to the furnace caused by the heating surface is disposed more reasonable. Using membrane wall structure on both sides of the furnace, both to ensure the sealing of the furnace, but also improves the thermal efficiency of the boiler.

Different natural gas steam boiler energy-saving measures as well as gas-fired boiler with environmental issues become more critical, more and more people are concerned about the importance of the environment for our development. Today, gas steam boilers in industrial production is very common, how to reduce the energy consumption of gas steam boilers, which we have been explored. We can take the following measures in natural gas steam boiler operation for energy. 1, the amount of steam needed for industrial production of a reasonable choice, and the number of the rated power station boiler steam boiler gas, in both cases the higher the degree of matching with the actual exhaust gas loss is smaller, the obvious energy saving. 2, the fuel in contact with air: fuel amount so that an appropriate amount of air and the optimum composition ratio of combustion, this would both improve fuel combustion efficiency and reducing emissions of polluting gases, energy to achieve the dual goals. 3, reducing the temperature of the exhaust gas steam boiler: the temperature of the boiler flue gas to reduce the effective use of exhaust heat generated in general, the efficiency of the boiler used is 85-88%, the exhaust gas temperature is 220-230 ℃. If the setting of energy-using the exhaust heat or the like, the exhaust gas temperature falls to 140-150 deg.] C, the boiler efficiency can be increased to 90-93%. 4, recycle heat from the boiler blowdown water: water using continuous blowdown heat by heat exchange, in addition to improving water temperature itching water to achieve energy saving gas steam boiler. At the same time, measures energy-saving gas steam boiler can also be reasonably recovered condensate heating system, and the heat of the condensate water recycling. It is different from the gas boiler and gas boiler: 1. Gas circulating fluidized bed combustion boiler coal by crushing device by the belt into the coal bin, by using multicast coal stoker wind, thrown into the furnace; circulating ash by heating, fluidized combustion process. After coal to gas and coke oven gas and purge gas mixed together by the four burners directly injected into the combustor. 2. Combustion of Coal is mainly composed of water and ash content and the elements C, H, O, N, S etc., the heat released by combustion of coal to produce SO2, SO3, NOx ash and moisture, and SO2, SO3, NOx discharged from the flue gas the atmosphere, pollute the environment, cause harm to humans. And the main component of coke oven gas and purge gas are CO and H2, after combustion, produce mainly CO2 and H2O, SO2 emissions relative gas boiler gas boiler, SO3, NOx is much less. 3. Usually ventilation negative pressure combustion gas boiler, the combustion process is to group together to complete the mating with the mating blower and induced draft fan, the coal combustion process, requires a lot of air and the furnace wall due to the leakage of the flue, the excess air coefficient of up to between 2.1-2.5. Gas boiler combustion slightly positive or slightly negative pressure, a small amount of wind required, air is preferably premixed with the gas within the combustor. No leakage factor positive pressure combustion flue and the furnace wall, the flue outlet air ratio operation may 1.05-1.2.4. Fuel explosive gas boiler combustion safety, the furnace explosion hazard unlikely to occur. The gas-fired boiler in the explosive concentration limits encountered fire will explode. More dangerous. 5. Gas boiler control difficult due to coal boiler, material thickness, amount of the blowing, the amount of the wind, the wind mixture ratio of coal and other reasons, to be automatically adjusted according to the operating parameters of the boiler load is large. Less impact on the factors of the gas boiler, the burner may be adjusted according to the size of the load valve, easy to achieve automatic control.

Long-term supply: Gas-fired steam boiler, gas 18tons szs hot water boiler shipped to argentinas, gas condensing boilers, low nitrogen gas-fired boiler, oil-fired boiler, electric steam boilers, electric hot water boiler.