When we use the gas boiler companies in faridabad cleaning and maintenance is very important that we first open the burner door in the use of gas-fired boiler, remove the rear housing panel, tighten the screws to open the rear side of the boiler clean mouth. Clean fuel gas piping with a wire brush. With a soft brush to clean the combustion chamber. Gas boiler to remove residue in the boiler, the cleaning opening is screwed on the screw, closing the burner door seal check is complete. If the boiler is installed in areas where temperatures below 0 ℃ must take the following precautions: If outside the boiler room, the room temperature drops below 15 ℃ or 18 ℃, the whole day operation of the boiler. If a long time no one in the room should be emptied of water in the boiler. You know cathodic protection of each member constituting the boiler (such as iron, copper, aluminum, etc.) of different materials. In order to prevent galvanic corrosion, cathodic protection measures must be taken. Sewage treatment boiler. The bottom of the gas-fired boiler flue gas emissions to prevent condensation. Since the flue gas is flue gas condensation (diesel or natural gas) and the flue gas temperature in the aqueous too low, water generated. A portion of the moisture is discharged from the chimney, the chimney wall is absorbed, the rest is deposited on the bottom of the chimney. Water produced by the following factors influence: flue gas temperature (efficiency 91%, the flue gas must be at a temperature of 170 ℃) where the total surface area heat chimney, chimney and chimney material. Maintenance of the burner. Gas boiler and burner maintenance, the best maintenance after steam supply. Because the products of combustion will corrode the boiler, clean up carbon deposits, therefore, not allow the products of combustion in the boiler memory stay too long.
Should be determined how a small gas steam boiler companies in faridabad phenomenon occurs when the minimum water level is less than the water level already defined, but still see the water level in the observed water level meter, is determined mild water; the water level when the water level is less than a meter visual when judged as a serious water shortage. The phenomenon outlined listed below: (1) drum water level is less than the normal water level defined; (2) low water alarm, automatic alarms sounded, signal light; (3) the superheated steam to increase the temperature of vapor; (4) the amount of water is not normal, below the steam flow rate value; (5) increase the temperature of vapor smoke emission.
According to the heat transfer mode, the heating surface of the boiler can be divided into a convection heat receiving surface, a radiation heating surface, and a semi-radiation heating surface. Convective heating surfaces include boiler tube bundles, economizers, superheaters, reheaters, air preheaters, and the like. The radiation heating surface includes a furnace, a water wall, and a half-radiation heating surface is a screen type superheater.
Obtain these honors the nation's largest gas-fired boiler companies in faridabad lab, China's first ultra-low nitrogen boiler FGR, China's first largest shell type boilers are inseparable from the party's determination to quickly adhere to independent innovation and square fast people keep trying. China Industrial Boiler Association statistics show that side quickly clean fuel boiler annual sales amount of the first nation. Last year, the company's sales revenue grew 39%, products in short supply.