Tel No. (+86) 371-55629010

cheap boilers for sale

Response to national environmental policy in recent years, Changzhi City, various enterprises and institutions from themselves, have the cheap boilers for sale environmental transformation and selection. However, due to various boiler plant manufacturers of products of varying quality, there is a variety of security risks in the operation; taking into account the level of professional fireman some units of non-compliance, the boiler operating procedures less skilled, the above reasons, Changzhi City Special inspection at this year's "safety month" held gas boiler safety planning activities of technical training courses, the city's use of gas-fired boiler units represent 233 enterprises and safety training. Fast boiler has a strong position in the field of clean-type gas boilers, and has a wealth of experience. Changzhi City, the special prosecutor of the special fast Boiler training for each unit represents.

You have to know the energy consumption of the cheap boilers for sale problem (to solve the problem of reheat steam temperature) to solve the problem of temperature reheat steam boiler measures 1 run 1.1AGC control measures to closely monitor fluctuations in the amount of coal, the fuel surge slashed appears when shall be conditioned for manual intervention by warm water. 1.2 artificially adjusting the load, increase or decrease the amount of coal can not be too large. 1.3 adjusted to optimize the combustion tests, the optimum value of oxygen boiler, the boiler properly regulate the amount of oxygen. 1.4 put into operation the burner adjustment mode, by adjusting a combustion temperature of the boiler reheat guaranteed. 1.5 Normal into the boiler reheat steam temperature control. 1.6 intense monitoring each stage reheater steam temperature, steam temperature adjustment for adjusting so that ground, the fine reduced spray desuperheater water, the control reheat steam temperature. 1.7 Test mastered by pulverizing system operation to change the influence of reheat steam temperature, analyze the causes and make predictable adjustments. 1.8 rational for sootblowing heating surface. 1.9 stratified fuel amount adjustment, reasonable control center of the flame, adjust a secondary air ratio, the excess air ratio changing, if necessary. 1.10 reheat section controls an amount of cold extraction. 1.11 administered with # 1, # 2 as soon as high pressure heater. 2 routine maintenance and testing 2.1 combustion adjustment experiment to determine the best mode of operation and control parameters boilers. 2.2 to detect and analyze the reasons offset the center of the furnace flame occurs, and take specific measures. 2.3 improve the quality of the reheat steam temperature control. 3 3.1 eliminate downtime desuperheating water leakage defects in the valves. 3.2 heating surface coking, fouling cleaning. 3.3 burner maintenance inspection, the swing angle position correction. 3.4 dredge preheater, treatment of flue leakage. 4 4.1 waterwall transformation, reheater, superheater tube cutting, check the internal corrosion and scaling conditions. 4.2 due to equipment problems reheat steam parameters less than the design value, or burner heating surface for transformation.

1, was dissolved gas steam cheap boilers for sale scale in effect: cleaning mainly be described in four aspects gas steam boiler steam boiler descaling pickling with acid. Hydrochloric acid and calcium scale in the steam boiler, carbonates and hydroxide and magnesium chloride to generate easily soluble, so that such a steam boiler scale dissolution. 2, a steam boiler scale peeling effect. Hydrochloride penetrate through the pores of scale inside the surface between the metal and chloride dissolve the scale, so that the scale adhering to the surface of the metal to share, peeled off. 3, loose scale effect in the steam boiler. After the mixing of silicate-containing scale, although they can not be dissolved by the reaction with hydrochloric acid, but the steam boiler scale doping in the carbonate and iron oxide were dissolved in hydrochloric acid solution, the residual scale becomes loose in the case of pickling of flow, they can easily be washed down. 4, the gas lift effect of the gas steam boiler scale. Hydrochloric acid and a large amount of carbon dioxide produced by the action of carbonate scale, in the process of escape for the steam boiler fouling layer dissolves more slowly or hardly soluble in, a certain lifting force, so that falling down from the wall of the steam boiler . The more ingredients carbonate scale, the more intense pickling this gas lift effect.

Good gas cheap boilers for sale, should have two advantages: the power source of development is inseparable from the boiler of the times, in many industrial boiler production plays an important role, but with the technological innovation and industrial production pattern of rapid changes, some of the old industrial age boiler products have been difficult to fully meet the needs of modern business, then how should the boiler business to stand out in a large number of boiler products it?