6T gas steam boiler plant 10t cheap belarus steam production is saturated steam it? In general yes, but it does not rule out the superheated steam. Saturated steam: soda boiling, water containing a large amount of steam; superheated steam: saturated steam heating was continued, the inside of the water into steam, a process called superheated steam is called superheated steam. Generally boiler pressure 1.6MPa, basically saturated steam; superheated steam is used to power ships, pressure 3.82MPa; special requirements but not exclusively, have seen 2.X pressure. Usually the steam temperature after the superheater is relatively high, it is necessary to cool to the desired temperature, the process temperature is called Save, Save mild surface divided spray desuperheater. Analyzing therefore saturated steam boiler or superheated steam, most direct way is to see if a desuperheater.
Factor one is that the working principle of condensing boiler plant 10t cheap belarus is well known to be different from that of ordinary boiler heating products, and the condensing boiler needs frequent contact with acidic substances such as water vapor in the course of operation. If the material used to produce condensing boiler belongs to the material which is easy to be corroded by acid material, the overall service life of boiler may be reduced.
According to instructions, "Neijiang City in 2017 and phase out coal-fired boiler plant 10t cheap belarus desulphurization facilities construction program of work", before the end of this year, the city built-up area will be fully phased out in Neijiang City, 10 steam tons / hour of coal-fired boilers and a total of 46 units. Among them, a small city in district out of coal-fired boilers 26, and phase out coal-fired small boilers Dongxing District 15, Neijiang Economic Development Zone small coal-fired boilers out of five. At the same time, accomplish four Chuansha Qi Industrial Co., Ltd. Two 20 tons of steam / hour or more coal-fired boiler desulphurization facilities. A ban on new urban area 20 steam tons / hour of coal-fired boilers, other counties (cities, districts) in principle, the new 10 steam tons / hour of coal-fired boilers. Out of the way including demolition scrap, coal to gas, coal and electricity upgrade boiler swap with large capacity.
We understand that the new Neijiang 20 tons of steam / hour for coal-fired boilers built-up areas, the new 10 steam tons / hour or less fixed asset investment projects in other areas of development and reform, economic and information technology departments will not be approved, approval and filing, environmental protection departments at all levels shall not pass environmental impact assessment, quality supervision departments at all levels do not accept the installation told not arrange supervision and inspection, no special equipment issued registration certificate. Quality supervision departments at all levels cancellation of special equipment for the boiler has been out of use registration certificate to prohibit the production of boiler manufacturers boiler does not meet industrial policy.
Gas boiler plant 10t cheap belarus need not require regular cleaning? For boilers harmful or beneficial? Many users faced with new gas boiler will be purchased by the existence of this confusion. The face of new, clean the boiler, it is necessary to do the cleaning job? In fact, from the boiler manufacturer's point of view, regular cleaning gas boiler necessity is very specific reasons, see below.